IMPORTANT SAFETY NOTICE Proper service and repair is important to the safe, reliable operation of all P&F Equipment. The service procedures recommended by P&F and described in this service manual are effective methods of performing service operations. Some of these service special tools should be used when and as recommended.
IMPORTANT SAFETY PRECAUTIONS Prior to shipment from the factory, our products are strictly inspected for recognized product safety and electrical codes of the countries in which they are to be sold. However, in order to maintain such compliance, it is equally important to implement the following precautions when a set is being serviced.
Page 6
3. Design Alteration Warning - Do not alter or add 7. Product Safety Notice - Some electrical and to the mechanical or electrical design of this TV mechanical parts have special safety-related receiver. Design alterations and additions, characteristics which are often not evident from including, but not limited to circuit modifications visual inspection, nor can the protection they give and the addition of items such as auxiliary audio...
Page 7
Precautions during Servicing A. Parts identified by the # symbol are critical for safety. Replace only with part number specified. B. In addition to safety, other parts and assemblies are specified for conformance with regulations applying to spurious radiation. These must also be replaced only with specified replacements.
Page 8
Safety Check after Servicing Examine the area surrounding the repaired location for damage or deterioration. Observe that screws, parts and wires have been returned to original positions. Afterwards, perform the following tests and confirm the specified values in order to verify compliance with safety standards. 1.
STANDARD NOTES FOR SERVICING Circuit Board Indications How to Remove / Install Flat Pack-IC 1. The output pin of the 3 pin Regulator ICs is 1. Removal indicated as shown. With Hot-Air Flat Pack-IC Desoldering Machine: Top View 1. Prepare the hot-air flat pack-IC desoldering Bottom View machine, then apply hot air to the Flat Pack-IC Input...
Page 10
3. The flat pack-IC on the CBA is affixed with glue, so With Soldering Iron: be careful not to break or damage the foil of each 1. Using desoldering braid, remove the solder from pin or the solder lands under the IC when all pins of the flat pack-IC.
Page 11
2. Installation With Iron Wire: 1. Using desoldering braid, remove the solder from 1. Using desoldering braid, remove the solder from all pins of the flat pack-IC. When you use solder the foil of each pin of the flat pack-IC on the CBA flux which is applied to all pins of the flat pack-IC, so you can install a replacement flat pack-IC more you can remove it easily.
Page 12
Instructions for Handling Semi- conductors Electrostatic breakdown of the semi-conductors may occur due to a potential difference caused by electrostatic charge during unpacking or repair work. 1. Ground for Human Body Be sure to wear a grounding band (1 MΩ) that is properly grounded to remove any static electricity that may be charged on the body.
CABINET DISASSEMBLY INSTRUCTIONS [40PFL4706/F7 (Serial No.: DS1)] 1. Disassembly Flowchart Step/ Fig. Loc. Part Removal Note This flowchart indicates the disassembly steps for the cabinet parts, and the CBA in order to gain access to PCB Holder D3 5(S-6) items to be serviced. When reassembling, follow the steps in reverse order.
Page 15
[4] Digital Main CBA Unit Shield Box (S-4) Wireless LAN Adaptor Jack Holder A (S-4) Separation Sheet (S-4) (S-5) Jack Holder B [5] Power Supply CBA Unit (S-5) Fig. D2 PL11.3-A_DC...
Page 16
(S-6) [6] PCB Holder (S-6) [9] AC Inlet Holder (S-6) Shield Plate [8] Speaker [11] IR Sensor (S-8) CBA Unit CL601 [7] Stand Bracket (S-7) Knob Frame [8] Speaker Function Button [10] Function CBA Unit (S-7) (S-7) Fig. D3 PL11.3-A_DC...
Page 17
[16] Front Cabinet [13] Panel Holder R (S-13) [15] LCD Module Assembly (S-11) (S-11) (S-9) (S-10) [14] Panel Holder L [12] Panel Holder B (S-12) (S-9) (S-12) Fig. D4 PL11.3-A_DC...
Page 18
TV Cable Wiring Diagram To LCD Module Assembly Power Supply CBA Unit Digital Main CBA Unit CN3101 Function CN3901 CBA Unit CN3801 CN3102 CN4001 To AC Inlet IR Sensor CBA Unit To Speaker CN4051 CN4052 Fig. D5 PL11.3-A_DC...
Page 19
[40PFL4706/F7 (Serial No.: DS2, DS3, XA1)] 1. Disassembly Flowchart Step/ Fig. Loc. Part Removal Note This flowchart indicates the disassembly steps for the cabinet parts, and the CBA in order to gain access to PCB Holder D3 5(S-6) items to be serviced. When reassembling, follow the steps in reverse order.
Page 21
[4] Digital Main CBA Unit Shield Box (S-4) Wireless LAN Adaptor Jack Holder A (S-4) (S-4) (S-5) Jack Holder B Separation Sheet [5] Power Supply CBA Unit (S-5) Fig. D2 PL11.3-A_DC...
Page 22
(S-6) [6] PCB Holder [9] AC Inlet Holder (S-6) (S-6) Shield Plate [8] Speaker (S-8) [11] IR Sensor CBA Unit CL601 [7] Stand Bracket (S-7) Knob Frame [8] Speaker Function Button (S-7) [10] Function CBA Unit (S-7) Fig. D3 4-10 PL11.3-A_DC...
Page 23
[17] Front Cabinet Corner Block A [15] Panel Holder T Corner Block A [13] Panel Holder R Corner Block A (S-13) (S-13) (S-11) (S-11) Corner Block A (S-9) (S-10) [12] Panel Holder B (S-9) (S-12) [16] LCD Module [14] Panel Assembly Holder L (S-12)
TV Cable Wiring Diagram To LCD Module Assembly Power Supply CBA Unit Digital Main CBA Unit CN3101 Function CN3901 CBA Unit CN3801 CN3102 CN4001 To AC Inlet IR Sensor CBA Unit To Speaker CN4051 CN4052 Fig. D5 4-12 PL11.3-A_DC...
ELECTRICAL ADJUSTMENT INSTRUCTIONS General Note: “CBA” is abbreviation for 1. Purity Check Mode “Circuit Board Assembly.” This mode cycles through full-screen displays of red, Note: Electrical adjustments are required after green, blue, and white to check for non-active pixels. replacing circuit components and certain 1.
Page 26
The White Balance Adjustment should be 5. Press [3] button to select the “HDB” for High Drive Blue adjustment. (“HDB” appears on the screen.) performed when replacing the LCD Panel 6. Press [MENU] button. The internal Raster signal or Digital Main CBA. appears on the screen.
Page 27
13. Press [9] button to select the “LDB” for Low Drive Blue adjustment (“LDB” appears on the screen.) and press [CH + or -] buttons to adjust the color temperature. Internal(Single) LDB 0 14. Press [7] button to select the “LDR” for Low Drive Red adjustment (“LDR”...
HOW TO INITIALIZE THE LCD TV The purpose of initialization is to place the set in a new out of box condition. The customer will be prompted to select a language and program channels after the set has been initialized. To put the program back at the factory-default, initialize the LCD TV using the following procedure.
FIRMWARE RENEWAL MODE Equipment Required (Files included in the USB storage device are displayed.) a. USB storage device " * " differs depending on the models. b. Remote Control Unit *****_******.upg Select an upgrade file Firmware Update Procedure *****_******.upg *****_******.upg 1.
TROUBLESHOOTING FLOW CHART NO.1 The power cannot be turned on. Replace Power Supply CBA Unit. See FLOW CHART NO.2 <The key operation is not functioning.> See FLOW CHART NO.3 <No operation is possible from remote control unit. (Operation is possible from the unit.)>...
Page 31
FLOW CHART NO.4 Picture does not appear normally. Replace Power Supply CBA Unit. Replace Power Supply CBA Unit. Replace Power Supply CBA Unit. FLOW CHART NO.5 Audio is not outputted normally. Replace Power Supply CBA Unit. Replace Digital Main CBA Unit. PL11.3TR...
SCHEMATIC DIAGRAMS / CBA AND TEST POINTS Standard Notes WARNING Many electrical and mechanical parts in this chassis have special characteristics. These characteristics often pass unnoticed and the protection afforded by them cannot necessarily be obtained by using replacement components rated for higher voltage, wattage, etc.
Page 37
LIST OF CAUTION, NOTES, AND SYMBOLS USED IN THE SCHEMATIC DIAGRAMS ON THE FOLLOWING PAGES: 1. CAUTION: CAUTION: FOR CONTINUED PROTECTION AGAINST RISK OF FIRE, REPLACE ONLY WITH SAME TYPE_A,_V FUSE. ATTENTION: UTILISER UN FUSIBLE DE RECHANGE DE MÊME TYPE DE_A,_V. 2.
Page 38
Digital Main 1 Schematic Diagram 1 NOTE: The order of pins shown in this diagram is different from that of actual IC3104. IC3104 is divided into eight and shown as IC3104 (1/8) ~ IC3104 (8/8) in this Digital Main Schematic Diagram Section. IC3704 CONTINUE DIGITAL MAIN CBA UNIT...
Page 39
Digital Main 2 Schematic Diagram 1 NOTE: The order of pins shown in this diagram is different from that of actual IC3104. IC3104 is divided into eight and shown as IC3104 (1/8) ~ IC3104 (8/8) in this Digital Main Schematic Diagram Section. DIGITAL MAIN CBA UNIT IC3104(2/8) MN2WS0170...
Page 40
Digital Main 3 Schematic Diagram 1 NOTE: The order of pins shown in this diagram is different from that of actual IC3104. IC3104 is divided into eight and shown as IC3104 (1/8) ~ IC3104 (8/8) in this Digital Main Schematic Diagram Section. (NO CONNECTION) CN3111 GND 2...
Page 41
Digital Main 4 Schematic Diagram 1 NOTE: The order of pins shown in this diagram is different from that of actual IC3104. IC3104 is divided into eight and shown as IC3104 (1/8) ~ IC3104 (8/8) in this Digital Main Schematic Diagram Section. JK3707 DIGITAL MAIN CBA UNIT SERVICE...
Page 42
Digital Main 5 Schematic Diagram 1 NOTE: The order of pins shown in this diagram is different from that of actual IC3104. IC3104 is divided into eight and shown as IC3104 (1/8) ~ IC3104 (8/8) in this Digital Main Schematic Diagram Section. DIGITAL MAIN CBA UNIT CONTINUE DIGITAL 8...
Page 43
Digital Main 6 Schematic Diagram 1 NOTE: The order of pins shown in this diagram is different from that of actual IC3104. IC3104 is divided into eight and shown as IC3104 (1/8) ~ IC3104 (8/8) in this Digital Main Schematic Diagram Section. IC3104(6/8) DIGITAL MAIN CBA UNIT MN2WS0170...
Page 44
Digital Main 7 Schematic Diagram 1 NOTE: The order of pins shown in this diagram is different from that of actual IC3104. IC3104 is divided into eight and shown as IC3104 (1/8) ~ IC3104 (8/8) in this Digital Main Schematic Diagram Section. CONTINUE DIGITAL 6 P-ON+3.3V...
Page 45
Digital Main 8 Schematic Diagram DIGITAL MAIN CBA UNIT R3607 Q3601 2SA1576UBTLQ C3604 OPEN (SWITCHING) R3608 R3609 R3610 4.7K D3614 180K IC3601 1SS133 R3631 Q3602 BD9329EFJ-E2 OPEN 2SC4081UBTLQ (+3.3V REG.) C3626 R3611 (SWITCHING) R3637 OPEN C3665 OPEN C3612 C3607 IC3606 C3609 C3616 C3610...
Page 46
Digital Main 9 Schematic Diagram SPEAKER R-CH CN3801 SP(R)- SP3801 C3802 C3816 SP(R)+ 0.47 470P C3806 D3803 D3804 C3804 C3815 SP(L)- R3881 OPEN OPEN OPEN 0.47 470P OPEN SP(L)+ SP3802 C3838 C3825 C3805 L3801 C3830 C3803 Q3801 L3802 470/16V 1000P 0.47 22uH 1000P...
Page 47
Digital Main 10 Schematic Diagram 1 NOTE: The order of pins shown in this diagram is different from that of actual IC3104. IC3104 is divided into eight and shown as IC3104 (1/8) ~ IC3104 (8/8) in this Digital Main Schematic Diagram Section. DIGITAL MAIN CBA UNIT CN3706 (ETHERNET CONNECTOR)
Page 48
Power Supply Schematic Diagram [40PFL4706/F7 (Serial No.: DS1, DS2)] CAUTION ! Fixed voltage (or Auto voltage selectable) power supply circuit is used in this unit. CAUTION ! : For continued protection against risk of fire, NOTE: If Main Fuse (F100) is blown , check to see that all components in the power supply replace only with same type 5 A, 250V fuse.
Page 49
Power Supply Schematic Diagram [40PFL4706/F7 (Serial No.: DS3, XA1)] CAUTION ! Fixed voltage (or Auto voltage selectable) power supply circuit is used in this unit. CAUTION ! : For continued protection against risk of fire, NOTE: If Main Fuse (F100) is blown , check to see that all components in the power supply replace only with same type 5 A, 250V fuse.
Page 50
Function Schematic Diagram FUNCTION CBA UNIT TO IR SENSOR CBA UNIT CN4051 CN4001 KEY-IN1 C4002 D4001 OPEN D4002 OPEN R4005 R4004 R4003 R4002 R4001 2.2K 2.7K 4.7K SW4006 SW4005 SW4004 SW4003 SW4002 SW4001 POWER CH UP SOURCE DOWN DOWN UNLESS OTHERWISE SPECIFIED: SWITCHES ARE SKRMAAE010.
Page 51
IR Sensor Schematic Diagram C4054 RS4051 GP1USC32XP (REMOTE SENSOR) D4051 SMLE12WBC7W1HR POWER TO DIGITAL MAIN R4051 R4052 R4053 CN4052 CBA UNIT CN3102 6.8K 4.7K 1 GND 2 REMOTE 3 AL+3.3V 4 P-ON+5V C4051 C4056 C4052 1000P 5 LED1 6 KEY-IN1 C4053 C4055 R4055...
Page 52
Power Supply CBA Top View [40PFL4706/F7(Serial No.:DS1,DS2)] CAUTION ! Fixed voltage (or Auto voltage selectable) power supply circuit is used in this unit. If Main Fuse (F100) is blown , check to see that all components in the power supply circuit are not defective before you connect the AC plug to the AC power supply.
Page 53
Power Supply CBA Bottom View [40PFL4706/F7(Serial No.:DS1,DS2)] CAUTION ! Fixed voltage (or Auto voltage selectable) power supply circuit is used in this unit. If Main Fuse (F100) is blown , check to see that all components in the power supply circuit are not defective before you connect the AC plug to the AC power supply.
Page 54
Power Supply CBA Top View [40PFL4706/F7 (Serial No.: DS3, XA1)] CAUTION ! Fixed voltage (or Auto voltage selectable) power supply circuit is used in this unit. If Main Fuse (F100) is blown , check to see that all components in the power supply circuit are not defective before you connect the AC plug to the AC power supply.
Page 55
Power Supply CBA Bottom View [40PFL4706/F7 (Serial No.: DS3, XA1)] CAUTION ! Fixed voltage (or Auto voltage selectable) power supply circuit is used in this unit. If Main Fuse (F100) is blown , check to see that all components in the power supply circuit are not defective before you connect the AC plug to the AC power supply.
EXPLODED VIEWS Cabinet [40PFL4706/F7 (Serial No.: DS1)] Digital Main CBA Unit LCD-1 CL3902 TH3104 USB-1 IR Sensor CBA Unit CL3001 CL3801 SP3802 CL601 CL5001 CL3101 SP3801 Power Supply CBA Unit CL4001 Function CBA Unit See Electrical Parts List for parts with this mark.
Page 59
Cabinet [40PFL4706/F7 (Serial No.: DS2, DS3, XA1)] 40PFL4706/F7 (Serial No.: DS2) 40PFL4706/F7 (Serial No.: DS3, XA1) Digital Main CBA Unit TH3104 USB-1 IR Sensor CBA Unit CL3001 CL3801 40PFL4706/F7 40PFL4706/F7 (Serial No.: DS2) (Serial No.: DS3, XA1) SP3801 LCD-1 CL601...
Page 61
PARTS LIST [40PFL4706/F7 (Serial No.: DS1)] Mechanical Parts PRODUCT SAFETY NOTE: Products marked with a Ref. No. Description Part No. # have special characteristics important to safety. DOUBLE SEMS SCREW M4X9 + BLACK 0EM408146A L0130UA Before replacing any of these components, read...
Page 62
Electrical Parts PRODUCT SAFETY NOTE: Products marked with a # have special characteristics important to safety. Before replacing any of these components, read carefully the product safety notice in this service manual. Don't degrade the safety of the product through improper servicing. NOTES: 1.
Page 63
PARTS LIST [40PFL4706/F7 (Serial No.: DS3, XA1)] Mechanical Parts PRODUCT SAFETY NOTE: Products marked with a # have special characteristics important to safety. Before replacing any of these components, read carefully the product safety notice in this service manual. Don't degrade the safety of the product through improper servicing.
Page 64
D..±0.5% F..±1% G..±2% J..±5% K..±10% M..±20% N..±30% Z..+80/-20% Different parts from the original model 40PFL4706/F7 (Serial No. : DS1) Ref. No. Description Part No. POWER SUPPLY CBA UNIT UPBPSPFSP004 DIGITAL ASSEMBLY A11P7MMA-003 Consists of the following DIGITAL MAIN CBA UNIT...
Need help?
Do you have a question about the 40PFL4706/F7 and is the answer not in the manual?
Questions and answers