Page 1
COMPACT DISC PLAYER CDP-D12 SERVICE MANUAL 1st Edition...
Page 2
Ce manual est destiné uniquement aux personnes compétentes en charge de l’entretien. Afin de réduire les risques de décharge électrique, d’incendie ou de blessure n’effectuer que les réparations indiquées dans le mode d’emploi à moins d’être qualifié pour en effectuer d’autres. Pour toute réparation faire appel à une personne compétente uniquement. CDP-D12...
Page 3
Sie die Batteriepole z.B. mit einem Klebestreifen ab oder geben Sie die Batterien einzeln in einen Plastikbeutel. This CDP-D12 is classified as a CLASS 1 LASER PRODUCT. The CLASS 1 LASER PRODUCT label is located on the top panel.
Manual Structure Purpose of this manual This manual is the service manual of Compact Disc Player CDP-D12. This manual is intended for use by trained system and service engineers, and describes the information required for parts-level service. Related manuals Beside this Service Manual, the following manuals are available for the unit.
Power consumption : 16 W (for J and CE) 30 cm from the surface of the objective lens on the optical 18 W (for UC and CN) pick-up block. 1-1-2. Installation Space Unit : mm CDP-D12...
SONY RK-G136 or equivalent RS232C D-sub 9-pin, Male D-sub 9-pin, Female 1-568-181-11 (connector) 1-563-375-11 (shell) CTRL-S Mini jack (φ3.5) Control-S connecting cable Accessory of CDP-D12 OPTICAL Square optical Optical digital connecting connector cable COAXIAL Pin jack Pin plug ANALOG OUTPUT (UNBAL)
Load impedance : 32 Z 1-1-5. Rack Mount _ _ _ _ _ EXT VIEW _ _ _ _ _ CDP-D12 can be mounted in the EIA standard 19-inch Pin No. Signal name rack. Remove the four feet in the bottom and mount it in the rack.
(CN1) on the SERVO board. PSW3 x 5 PSW3 x 5 Front panel CD mechanism deck Step Flexible card wire assembly HP board tapping (CN571) screws Flexible card wire SERVO board (CN1) BVTT3 x 5 AC/SW board (CN3) BVTT3 x 5 Chassis (sub) CDP-D12...
Page 14
6. Install the chassis (T388) assembly by reversing steps Bracket (CD) PTT2.6 x 6 1 to 3 of removal. Chassis (T388) assembly Precision P2 x 3 Precision P2 x 3 PTT2.6 x 6 SERVO board Solders Blue Claw Black CDP-D12...
Page 15
5. Remove the three screws and remove the SERVO board. 6. Install the new SERVO board by reversing the steps of removal. SERVO board Special screw Solders Special screws Guide (DISC M) SENSOR board White Solders Yellow Black Chassis (T388) assembly LO motor assembly CDP-D12...
Page 16
4. Remove the two precision screws and remove the LO motor sub assembly from the bracket (motor). 5. Install the new LO motor sub assembly by reversing Tension spring (RA) the steps of removal. Bracket (motor) Precision P2 x 2 LO motor sub assembly CDP-D12...
Page 17
9. Install the new floating block assembly by reversing the steps of removal. Fig. 1 Lock Yellow black LOAD SW Solders board Floating block assembly Protruded portion Compression spring (FL) Compression springs (FL) Roading ring Lever (D) Dampers (T) Damper (T) Tension spring (KF1) CDP-D12...
Page 18
(driving). 9. Install the new sled motor by reversing the steps of removal. Hook LIMIT SW board Floating block assembly Rail Floating block assembly Sled motor Solders white Harness Yellow Hook Precision Base (driving) P1.4 x 3 1-10 CDP-D12...
The fuse should be replaced with following parts after removing the foreign matter. Chucking arm assembly Ref No. Board name Sony part No. POWER board ! 1-533-449-11 (for J/U) ! 1-532-215-00 (for CE/CN) 1. Remove the cover. (Refer to 1-3. “Removing the Cabinet”.) 2.
M2.6 P=0.45 millimeter-screw (equivalent to JAE D20418-JF) The above screws are supplied with the respective connec- tors. Therefore, they are not supplied as the service parts. If the screws alone are required, purchase them on the commercial market. 1-12 CDP-D12...
Therefore, specified parts should be used in the case of replacement. 2. Standardization of Parts Some repair parts supplied by Sony differ from those used for the unit. These are because of parts common- ality and improvement. Parts list has the present standardized repair parts.
X-2335-620-1 s PANEL ASSY, FRONT 1-827-546-11 s CABLE, FLEXIBLE FLAT (19 CORE) 3-704-366-01 s SCREW, CASE M3X8 (EP-FE/ZNBK) 2-335-924-31 s BUTTON 4-942-568-41 s EMBLEM (N0.5),SONY 4-951-620-01 s SCREW(2.6X8)+BVTP(TAPPING)(ST) 2-338-688-01 s SCREW, STEP TAPPING 2-346-661-11 s BUTTON (P) 4-983-657-01 s KNOB (AMS)
Page 23
!1-738-531-11 s CORD, POWER (U/C) (For UC model) 1-827-545-11 s CABLE, FLEXIBLE FLAT (30 CORE) 3-670-155-11 s FOOT 4-217-350-01 s STOPPER, CORD 7-682-946-09 s SCREW +PSW 3X5 7-685-647-79 s SCREW +BVTP3X10 7-685-792-09 s SCREW,+PTT 2.6X6 7-685-870-09 s SCREW BVTT 3X5 CDP-D12...
Page 24
3-040-034-01 s SPRING (RA), TENSION 3-040-040-21 s ARM (ROLLER) 3-040-042-01 s WASHER 3-040-044-01 s ROLLER (S) 3-043-880-01 s RING (RA) RETAINING (PETP) 3-241-292-11 s SCREW, SPECIA 3-241-292-31 s SCREW, SPECIAL 7-627-553-17 s SCREW,PRECISION +P2X2 7-627-553-37 s SCREW,PRECISION +P 2X3 7-685-781-09 s SCREW,+PTT 2X4 CDP-D12...
3-040-033-01 s SPRING (KF1), TENSION 3-048-258-01 s SPRING (8) (K) 3-220-180-01 s SPRING (TR2) TENSION 3-913-404-01 s RETAINER (DISC) 3-931-881-11 s LEVER (LOCK) 3-931-882-02 s GEAR (MDL) 3-931-894-01 s BRACKET (CP) 3-935-828-01 s LEVER (D) 7-627-553-17 s SCREW,PRECISION +P2X2 CDP-D12...
Page 26
1-823-951-11 s FLEXIBEL FLAT CABLE 6P 3-040-029-01 s SPRING (SL), TORSION 3-040-030-01 s SPRING (FEED), PLATE 3-040-045-01 s BASE (DRIVING) 3-040-194-01 s GEAR (SL MIDWAY) 3-909-607-01 s SCREW !8-820-165-06 s DEVICE, OPTICAL KSS-721A/C-RP 7-627-553-37 s SCREW,PRECISION +P 2X3 7-627-850-28 s SCREW,PRECISION +P1.4X3 CDP-D12...
1-131-992-11 s CAP, CERAMIC 100000PF F 1608 C793 1-131-992-11 s CAP, CERAMIC 100000PF F 1608 CN791 1-568-942-11 o PIN,CONECTOR (4P) IC702 8-749-016-97 s IC NJL62H400A R790 1-216-809-11 s RESISTOR,CHIP 100 1/10W 1608 R792 1-216-805-11 s RESISTOR,CHIP 47 1/10W 1608 S791 1-762-875-21 s SWITCH, KEYBOARD CDP-D12...
Page 28
1-126-933-11 s CAPACITOR,ELECT 100MF/16V C611 1-131-992-11 s CAP, CERAMIC 100000PF F 1608 C220 1-128-551-11 s CAPACITOR ELECT 22MF/63V C612 1-131-992-11 s CAP, CERAMIC 100000PF F 1608 C221 1-126-934-11 s CAPACITOR,ELECT 220MF/16V C613 1-131-992-11 s CAP, CERAMIC 100000PF F 1608 CDP-D12...
Page 29
6-701-111-01 s IC AK4382AVT-E2 8-719-046-07 s DIODE 2A02 8-719-046-07 s DIODE 2A02 IC103 8-759-385-17 s IC NJM4580E (TE2) IC104 8-759-041-46 s IC L78M05TLL-SONY-TL 8-719-046-07 s DIODE 2A02 IC121 8-759-385-17 s IC NJM4580E (TE2) 8-719-046-07 s DIODE 2A02 IC151 8-759-385-17 s IC NJM4580E...
Page 30
R411 1-249-429-11 s RESISTOR,CARBON(SMALL)10K 1/4W R156 1-215-440-00 s RESISTOR,METAL FILM 6.2K 1/4W R412 1-216-833-11 s RESISTOR,CHIP 10K 1/10W (1608) R157 1-215-435-00 s RESISTOR,METAL FILM 3.9K 1/4W R413 1-249-429-11 s RESISTOR,CARBON(SMALL)10K 1/4W R414 1-216-833-11 s RESISTOR,CHIP 10K 1/10W (1608) 2-10 CDP-D12...
Page 31
1-249-417-11 s RESISTOR,CARBON 1K 1/4W(SMALL) R621 1-249-417-11 s RESISTOR,CARBON 1K 1/4W(SMALL) R622 1-216-827-11 s RESISTOR, CHIP 3.3K 1/10W 1608 R623 1-249-417-11 s RESISTOR,CARBON 1K 1/4W(SMALL) R624 1-249-417-11 s RESISTOR,CARBON 1K 1/4W(SMALL) R625 1-216-827-11 s RESISTOR, CHIP 3.3K 1/10W 1608 2-11 CDP-D12...
Page 32
1-216-841-11 s RESISTOR, CHIP 47K 1/10W 1608 1-216-841-11 s RESISTOR, CHIP 47K 1/10W 1608 1-216-809-11 s RESISTOR,CHIP 100 1/10W 1608 1-216-809-11 s RESISTOR,CHIP 100 1/10W 1608 1-216-864-11 s CONDUCTOR, CHIP (1608) 1-216-809-11 s RESISTOR,CHIP 100 1/10W 1608 1-216-833-11 s RESISTOR,CHIP 10K 1/10W (1608) 2-12 CDP-D12...
HN102 1-827-545-11 s CABLE, FLEXIBLE FLAT (30 CORE) (CN404/MAIN board to CN1/SERVO board) HN103 1-676-707-11 s PWB, PICK UP FLEXIBLE (CN2/SERVO board to OPTICAL PICK-UP block) HN104 1-823-951-11 s FLEXIBEL FLAT CABLE 6P (CN3/SERVO board to CN13/SW board) 2-13 CDP-D12...
Page 35
In addition, for semiconductors with ID Nos., refer to the separate CD-ROM titled “Semiconductor Pin Assignments” (Sony Part No. 9-968-546-xx) that allows searching for parts by semiconductor type or ID No. The semiconductors in the manual or on the CD-ROM are listed by equivalent types.
Circuit Description signal processing block. The audio data is output to the The compact disc player CDP-D12 consists of the five MAIN board. circuit boards are described below excluding the option boards.
SUFFIX: -32 (for J) SUFFIX: -12 (for UC) SUFFIX: -12 (for UC) POWER POWER A SIDE (Component side) B SIDE (Solder side) B SIDE (Solder) Pattern B SIDE (Solder) Pattern SUFFIX: -22 (for CE, CN) SUFFIX: -22 (for CE, CN) CDP-D12...
A SIDE (Component side) SUFFIX: -11 SUFFIX: -11 B SIDE (Solder) Pattern B SIDE (Solder) Pattern SUFFIX: -11 SUFFIX: -11 LOAD LOAD A SIDE (Component side) B SIDE (Solder side) B SIDE (Solder) Pattern B SIDE (Solder) Pattern SUFFIX: -11 SUFFIX: -11 CDP-D12...
Page 53
2 V AC range are suitable. (See Fig. A) To Exposed Metal Parts on Set 0.15 µ F 1.5 k Z voltmeter (0.75V) Earth Ground Fig A. Using an AC voltmeter to check AC leakage. CDP-D12...
Need help?
Do you have a question about the CDP-D12 and is the answer not in the manual?
Questions and answers