FILE NO. SERVICE MANUAL Multimedia Projector Model No. PLC-XW10 U.S.A., Canada, Europe, Asia, Africa Original Version Chassis No. MP6-XW1000 NOTE: Match the Chassis No. on the unit’s back cover with the Chassis No. in the Service Manual. If the Original Version Service Manual Chassis No.
Safety Instructions SAFETY PRECAUTIONS WARNING: The chassis of this projector is isolated (COLD) from AC line by using the converter transformer. Primary side of the converter and lamp power supply unit circuit is connected to the AC line and it is hot, which hot circuit is iden- tified with the line ( ) in the schematic diagram.
Specifications Projector Type Multi-media Projector Dimensions (W x H x D) 7.44” x 2.93” x 11.42” (189mm x 74.5mm x 290mm) Net Weight 5.51 lbs (2.5 kg) LCD Panel System 0.7” TFT Active Matrix type, 3 panels Panel Resolution 1024 x 768 dots Number of Pixels 2,359,296 (1024 x 768 x 3 panels) Color System...
Note on Servicing When you carry out the electrical, optical service adjustment or repairing with cabinet top removal, it should be done under the service conditions listed below. If you can not keep the one of following conditions, the projector turns off automatically by operating the protection circuit.
Circuit Protections This projector is equipped with the following circuit protections to operate in safety. If the abnormality occurs inside the projector, it will automatically turn off by operating one of the following protection circuits. Fuse The fuse is located inside of the projector. When either the LAMP indicator or the READY indicator is not illuminat- ed, fuse may be opened.
Circuit Protections Warning temperature and power failure protection The TEMP WARNING indicator flashes red and the projector will automatically turn off when the internal tempera- ture of the projector exceeds the normal temperature or when stopping cooling fans or when the internal power supply lines are failed.
Mechanical Disassemblies Mechanical disassemble should be made following procedures in numerical order. Following steps show the basic procedures, therefore unnecessary step may be ignored. Caution: The parts and screws should be placed exactly the same position as the original otherwise it may cause loss of performance and product safety.
Page 9
Mechanical Disassemblies 3. MAIN BOARD REMOVAL Remove 9 screws and remove the main board upward. Main Board Fig.3 FUSE REMOVAL Remove a screw and pull the line filter cover upward and then replace the fuse if required. Line Filter Cover Fuse Fig.4...
Page 10
Mechanical Disassemblies 4. AV AND COMPONENT BOARD REMOVAL 1) Remove 3 screws and FPC cables, and then take the component board off upward. 2) Remove a screw and a grounding lead, and then take the AV board ass’y Component Board off upward.
Page 11
Mechanical Disassemblies 6. LAMP BALLAST UNIT FAN REMOVAL (FN905) 1) Disconnect the thermal switch sockets. 2) Remove a screw and disconnect the lamp socket. 3) Remove 2 screws (bottom side) and a screw , and the remove the lamp ballast unit upward. 4) Take the cover off from the lamp ballast unit and remove 4 screws and take the lamp ballast board off from the...
Page 12
Mechanical Disassemblies 8. OPTICAL UNIT AND FAN REMOVAL (FN901) 1) Remove 2 screws A and the thermal switch. 2) Remove a screw B and disconnect the lamp socket. 3) Remove 7 screws and pull the optical unit upward. 4) Remove 2 screws D and fan (FN901). Thermal Switch Optical Unit Lamp Socket...
Mechanical Disassemblies 10. FANS REMOVAL (FN902, FN903, FN904) 1) Remove 4 screws A and 3 screws B and remove the duct cover and fans (FN902 and FN903). 2) Remove 2 screws C and fan (FN904), and remove 2 screws D and fan holder. Duct Cover FN902 FN903...
Optical Parts Disassemblies 1. PROJECTION LENS REMOVAL 1) Remove the Cabinet top and cabinet front following to “Mechanical Disassemblies”. 2) Remove 4 screws and remove the Projection Lens. Fig.1 2. OPTICAL UNIT TOP REMOVAL 1) Remove the Cabinet top, front, main board, component boards and power unit cover following to “Mechanical Disassemblies”.
Page 15
Optical Pats Disassemblies 3. INTEGRATOR LENS ASS’Y DISASSEMBLY 1) Remove the cabinet top, front and main board following to “Mechanical Disassemblies”. 2) Remove 2 screws and take the integrator lens ass’y off upward. 3) Release 4 hooks on the holder and remove the integrator lens. Hooks *Should be place the rugged surface of lens...
Page 16
Optical Parts Disassemblies 5. POLARIZED GLASS-IN ASS’Y DISASSEMBLY 1) Remove the cabinet top, front, main and component boards following to “Mechanical Disassemblies”. 2) Remove each screw and take the each polarized glass-in ass’y off upward. 3) Release 2 hooks and remove the polarized glass-in. Phase Sheet Polarized Glass-In Hook...
Optical Parts Disassemblies Locations and Directions When the optical parts mounting or assembling, the parts must be mounted in the specified location and direction. Please follow to the figure below. Part name Part name Prism ass’y Relay lens (OUT) Integrator lens (IN) Relay lens (IN) Integrator lens (OUT) Dichroic mirror (G)
LCD Panel/Prism Ass’y Replacement IMPORTANT NOTICE on LCD Panel/Prism Ass'y Replacement LCD panels used for this model can not be replaced separately. Do not disassemble the LCD Panel/Prism Ass’y. These LCD panels are installed with precision at the factory. When replacing the LCD panel, should be replaced whole of the LCD panels and prism ass’y at once.
Lamp Replacement WARNING: ORDER REPLACEMENT LAMP - For continued safety, replace with a lamp assembly of the same type. Type No. Service Parts No. - Allow the projector to cool for at least 45 minutes before you open the POA-LMP31 610 289 8422 lamp cover.
Optical Adjustments CONTRAST ADJUSTMENT [Before Adjustment] - Adjustment requires a 2.0mm hex wrench and a slot screwdriver. - Remove cabinet top following to “Mechanical Disassemblies”. - Input a 100% of black raster signal. Note: Do not disconnect the connectors on main and component boards otherwise the projector can not be turned on.
Optical Adjustments INTEGRATOR LENS ADJUSTMENT [Before Adjustment] - Adjustment requires a 2.0mm hex driver and a slot screwdriver. - Remove cabinet top following to “Cabinet Disassemblies”. Note: Do not disconnect the connectors on main and component boards otherwise the projector can not be turned on. Yellow [ADJUSTMENT] 1.
Optical Adjustments RELAY LENS ADJUSTMENT [Before Adjustment] - Adjustment requires a 2.0mm hex driver and a slot screwdriver. - Remove cabinet top following to “Cabinet Disassemblies”. Note: Do not disconnect the connectors on main and component boards otherwise the projector can not be turned on. [ADJUSTMENT] White 1.
Electrical Adjustments Service Adjustment Menu Operation To enter the service mode To enter to the “Service Mode”, press and hold the MENU and NORMAL button on the projector at the same time for more than 3 seconds. The service mode display appears on the screen as follows. To adjust service data Select the adjustment item no.
Electrical Adjustments Circuit Adjustments CAUTION: The each circuit has been made by the fine adjustment at factory. Do not attempt to adjust the follow- ing adjustments except requiring the readjustments in servicing otherwise it may cause loss of perfor- mance and product safety. [Adjustment Condition] Input signal Video signal ......
Page 25
Electrical Adjustments PC GAIN ADJUSTMENT COMPONENT GAIN ADJUSTMENT 1. Receive the 16-step grey scale computer signal. 1. Receive the 16-step grey scale component video sig- 2. Set to COMPUTER mode. nal. 2. Set to VIDEO (Component) mode. [PC-R GAIN ADJUSTMENT] 3.
Page 26
Electrical Adjustments PSIG ADJUSTMENT PC/AV GAMMA OFF ADJUSTMENT 1. Receive the 16-step grey scale computer signal. PC-GAMMA OFF ADJUSTMENT 2. Set to COMPUTER mode. 1. Receive the 16-step gray scale computer signal. 3. Connect an oscilloscope to test point “TP1451” (+) 2.
Page 27
Electrical Adjustments PC/AV-VIDEO ADJUSTMENT-1 PC/AV-VIDEO ADJUSTMENT-2 Presetting [PC-VIDEO ADJUSTMENT-2] 1. Input the 16-step gray scale video signal and com- 1. Receive the 16-step grey scale computer signal. puter signal. 2. Set to COMPUTER mode. 3. Connect an oscilloscope to test point “TP503G” (+) [PC/AV-VIDEO ADJUSTMENT] and chassis ground (-).
Page 28
Electrical Adjustments COMMON CENTER ADJUSTMENT BLACK BALANCE ADJUSTMENT 1. Receive the 1 dot line computer signal. [PC BLACK BALANCE ADJUSTMENT] 2. Set to COMPUTER mode. 1. Receive the 16-step grey scale computer signal. 2. Set to COMPUTER mode. [R-COMMON CENTER ADJUSTMENT] 3.
Electrical Adjustments Service Adjustment Data Table These initial values are the reference data written from the CPU ROM to the memory IC when the new memory IC replaced. The adjustment items indicated with “ ” are required to readjust fol- lowing to the “Electrical adjustments”.
Electrical Adjustments Initial Value Adjustment Item Range Description For Fan Control 0 - 31 2 - 5 Temperature checking period, 0.5/1.0/1.5/2.0/2.5/3.0 sec. 0 - 255 0 - 255 0 - 255 0 - 255 0 - 255 Not used Sub Sharpness (YCbCr) 0 - 15 Refer to User control spec Sub Tint (Video)
Troubleshooting NO POWER Refer to next page IIC BUS PSDA PSDA KEY SWITCHES ON/OFF BUTTON 17-18 KEY SW INDICATOR POWER LED Check that the LAMP LAMP indicator and READY IC1803 indicator are lighting. READY LED IC301 If both of indicators READY SYSTEM are not lighting,check...
Page 33
Troubleshooting IIC BUS PSDA PSDA TEMP. BOARD TEMP. TEMP. SENSOR SENSOR IC2831 IC2832 Abnormal temperature detection on the Main board. Abnormal temperature detection inside of the projector. Is projection of lamp cover inside broken or not fitting correctry ? Check the interlock switch (SW904) SW904 and lamp cover.
Page 34
Troubleshooting NO POWER PERIPHERY OF CHASSIS MAIN BOARD 1. Is fuse (F601) blown? 1. Check that the 15.5V is observed at pins 1-3 of K3C. Fuse may be opened when either the LAMP indica- 2. Check that the 6V is observed at pins 6-8 of K3C. tor or the READY indicator isn't Illuminated.
Troubleshooting NO PICTURE 2. Check that the PC/AV switching signal is correct. AV BOARD Pin 16 of IC5201 ........AV: H, PC: L Pin 5 of IC5282........AV: H, PC: L 1. Check that the Vcc-voltages(+5V, -5V) are applied to 3. Check that the RGB signals are observed at follow- AV circuits.
Troubleshooting NO SOUND MAIN BOARD AUDIO BOARD 1. Check that the PC/AV switching signal is correct. 1. Check that sound volume control signal is correct. Pins 10 and 11 of IC5001 ......AV : L Pin 4 of IC001 PC : H 2.
Control Port Functions System Control & I/O Port Functions IC Ref. No Pin/Name Signal Name Function Note IC301 PortA0 ROMWEL For ICE PortA1 ROMWEH For ICE PortA2 BOOTWE For ICE PortA3 Not used Fixed High PortA4 5V_SW Power ON/OFF MainPower-ON: High PortA5 LAMP_BST_SW Lamp Ballast ON/OFF...
Waveforms TP207 TP218 TP7223 TP208 AV VIDEO H-SYNC TP221R TP7224 TP221G TP221B V-SYNC VIDEO TPDHS TPDVS TP1401 TP1451 TP2211R PSIG for R/B R-OUTPUT and G -38-...
Cleaning After long periods of use, dust and other particles will accumulate on the LCD panel, prism, mirror, polarized glass, lens, etc., causing the picture to darken or color to blur. If this occurs, clean the inside of optical unit. Remove dust and other particles using air spray.
Pin description of diode, transistor and IC Diode Diode K: Cathode A: Anode Transistor/FET Transistor/FET C: Collector D: Drain B: Base G: Gate Index E: Emitter S: Source C1 C2 C1 C2 (GND) RESET (IN) (OUT) Index Index Index Index Index Index Index...
Parts description and reading in schematic diagram 1. The parts specification of resistors, capacitors and Resistor Reading coils are expressed in designated code. Please check Example 1/2 D J 10K B the parts description by the following code table. 2. Some of transistors and diodes are indicated in mark Characteristic for the substitution of parts name.
MP6-XW1000 Electrical Parts List Product safety should be considered when a component replacement is made in any area of a projector. Components indicated by a mark in this parts list and the circuit diagram show components whose value have special significance to product safety. It is particularly recommended that only parts specified on the following parts list be used for components replacement pointed out by the mark.
Page 54
MP6-XW1000 Electrical Parts List Note: Parts order must contain Chassis No., Part No., and Descriptions. OUT OF CIRCUIT BOARD Main Board RC Board Filter Board Temp Board F601 Fuse Component FN905 Board Cooling Fan LCD/Prism Ass’y FN903 Cooling Fan A901 Lamp Ballast Unit FN902...
Page 55
MP6-XW1000 Electrical Parts List Ref. No. Part No. Description Ref. No. Part No. Description OUT OF CIRCUIT BOARDS Q5003 405 014 4509 TR 2SC2412K T146 R 405 014 4608 TR 2SC2412K T146 S 405 015 8704 TR 2SC2812-L6-TB LP900 610 289 8422 ASYY, LAMP (POA-LMP31) 405 015 8902 TR 2SC2812-L7-TB...
Page 56
MP6-XW1000 Electrical Parts List Ref. No. Part No. Description Ref. No. Part No. Description 405 015 8704 TR 2SC2812-L6-TB IC311 409 480 1307 IC PST573IM 405 015 8902 TR 2SC2812-L7-TB 409 480 1307 IC PST573IM Q5296 405 134 5905 TR 2SA1037AK-T146-R IC312 409 350 2908 IC TC7W126FU-(TE12L)
Page 57
MP6-XW1000 Electrical Parts List Ref. No. Part No. Description Ref. No. Part No. Description C1500 403 280 0805 ELECT 330U M 6.3V C236 403 298 9609 CERAMIC 0.1U K C1501 403 164 0204 CERAMIC 0.1U Z 403 325 3303 CERAMIC 0.1U K C1502 403 215 2201...
Page 58
MP6-XW1000 Electrical Parts List Ref. No. Part No. Description Ref. No. Part No. Description C3306 403 322 7809 ELECT 220U M 6.3V C5001 403 205 7803 TA-SOLID 2.2U M C3307 403 164 0204 CERAMIC 0.1U Z C5002 403 205 7803 TA-SOLID 2.2U M C3331...
Page 59
MP6-XW1000 Electrical Parts List Ref. No. Part No. Description Ref. No. Part No. Description C5269 403 215 2904 CERAMIC 0.022U K C7222 403 149 9208 CERAMIC 0.01U Z C5273 403 157 1904 CERAMIC 10P D C7225 403 157 3809 CERAMIC 120P J C5275 401 105 7909...
Page 60
MP6-XW1000 Electrical Parts List Ref. No. Part No. Description Ref. No. Part No. Description 645 031 3325 R-NETWORK 100X4 1/16W R1506 401 105 7909 MT-GLAZE 0.000 ZA 1/16W RB6103 645 021 0358 R-NETWORK 100X4 0.063W R1507 401 105 7909 MT-GLAZE 0.000 ZA 1/16W 645 031 3325 R-NETWORK 100X4 1/16W...
Page 61
MP6-XW1000 Electrical Parts List Ref. No. Part No. Description Ref. No. Part No. Description R1587 401 105 7909 MT-GLAZE 0.000 ZA 1/16W R1972 402 079 7704 FUSIBLE RES 1.0 JH 1/4W R1590 401 105 7909 MT-GLAZE 0.000 ZA 1/16W R1973 402 080 7007 FUSIBLE RES 1.8 JH...
Page 62
MP6-XW1000 Electrical Parts List Ref. No. Part No. Description Ref. No. Part No. Description R2877 401 105 7909 MT-GLAZE 0.000 ZA 1/16W R3361 401 105 0306 MT-GLAZE 10 JA 1/16W R2878 401 105 0405 MT-GLAZE 100 JA 1/16W R3362 401 105 0306 MT-GLAZE 10 JA 1/16W R2879...
Page 63
MP6-XW1000 Electrical Parts List Ref. No. Part No. Description Ref. No. Part No. Description R3883 401 105 0603 MT-GLAZE 10K JA 1/16W R5003 401 105 0702 MT-GLAZE 100K JA 1/16W R3884 401 105 0405 MT-GLAZE 100 JA 1/16W R5004 401 105 0702 MT-GLAZE 100K JA 1/16W R3891...
Page 64
MP6-XW1000 Electrical Parts List Ref. No. Part No. Description Ref. No. Part No. Description R5202 401 105 0306 MT-GLAZE 10 JA 1/16W R5289 401 105 7909 MT-GLAZE 0.000 ZA 1/16W R5203 401 105 0306 MT-GLAZE 10 JA 1/16W R5291 401 113 4402 MT-GLAZE 75 JA 1/16W R5204...
Page 65
MP6-XW1000 Electrical Parts List Ref. No. Part No. Description Ref. No. Part No. Description R6122 401 105 7909 MT-GLAZE 0.000 ZA 1/16W R6913 401 105 7909 MT-GLAZE 0.000 ZA 1/16W R6123 401 105 7909 MT-GLAZE 0.000 ZA 1/16W R6914 401 105 7909 MT-GLAZE 0.000 ZA 1/16W R6126...
Page 66
MP6-XW1000 Electrical Parts List Ref. No. Part No. Description Ref. No. Part No. Description R7288 401 105 7909 MT-GLAZE 0.000 ZA 1/16W L5102 645 020 1776 INDUCTOR,3.3U M R802 401 105 0603 MT-GLAZE 10K JA 1/16W L5106 645 020 1776 INDUCTOR,3.3U M R803 401 105 0603...
Page 67
MP6-XW1000 Electrical Parts List Ref. No. Part No. Description Ref. No. Part No. Description 645 037 5187 OSC,CERAMIC 8.00MHZ R1021 401 105 0405 MT-GLAZE 100 JA 1/16W X3861 645 024 8566 OSC,CERAMIC 6.00MHZ R1024 401 105 0504 MT-GLAZE 1K JA 1/16W 645 037 5217 OSC,CERAMIC 6.00MHZ R1026...
Page 68
MP6-XW1000 Electrical Parts List Ref. No. Part No. Description Ref. No. Part No. Description L2012 403 366 6202 CERAMIC 22U Z TRANSISTOR L2013 403 366 6202 CERAMIC 22U Z Q2651 405 014 4509 TR 2SC2412K T146 R L2016 645 014 2659 FILTER,EMI 10MHZ 405 014 4608 TR 2SC2412K T146 S...
Page 69
MP6-XW1000 Electrical Parts List Ref. No. Part No. Description Ref. No. Part No. Description C2643 403 149 9208 CERAMIC 0.01U Z R2653 401 113 6208 MT-GLAZE 3.6K JA 1/16W C2651 403 229 3508 ELECT 100U M R2654 401 105 7909 MT-GLAZE 0.000 ZA 1/16W C2652...
Page 70
MP6-XW1000 Electrical Parts List Ref. No. Part No. Description Ref. No. Part No. Description R6688 401 198 7909 MT-GLAZE 47 JA 401 037 5004 MT-GLAZE 0.000 ZA 1/10W R6689 401 198 7909 MT-GLAZE 47 JA 401 037 5004 MT-GLAZE 0.000 ZA 1/10W R6691 401 105 0504 MT-GLAZE...
Schematic Diagrams PLC-XW10 LINE FILTER MP6A HOT SIDE COLD SIDE ASSY,PWB, TERMOSTAT 1AA0B10C3110B INTER LOCK (SET TO OPEN AT 100+/-5˚C) SW904 SW902 C603 C604 S10B3370N K903S C601 C602 K901S J11EA321G F601 VA601 R601 L601 L602 275GM J11B S10B3590N 275GM 275GM...
Printed Wiring Board Diagrams CAUTION (LV-7105U/E) This projector is isolated from AC line by using the internal converter transformer. Please pay attention to the following notes in servicing 1. Do not touch the part on hot side (primary circuit) or both parts on hot and cold sides (secondary circuit) at the same time.
Page 91
AV Board (SIDE:A) R/C Board (SIDE:A) AV Board (SIDE:B) R/C Board (SIDE:B) Main Board “K8D” Component Board (SIDE:A) Component Board (SIDE:B) Main Board “K33B” R-LCD B-LCD Panel Panel G-LCD Panel Main Board “K33R” FN902 FN904 “K33G” “K8A” Main Board (PCB_MP6PA/PP6PA)
Page 92
Main Board (SIDE:A) Main Board (SIDE:B) Audio Amp Speaker Board “K6T” Component Board “K3B” FN905 Board Component “K28D” Board Temp “K3R” Board FN903 “K8H” Lamp Ballast Unit Audio Amp Component Board “K6P” Board “K3G” Component Board “K3A” Power Board “K6J” FN901 Power Board...
Need help?
Do you have a question about the PLC-XW10 and is the answer not in the manual?
Questions and answers